Category Trailer Mods / Repairs

Modify RV Air Conditioning System Digital Thermostat

December 26, 2016 Trailer Mods / Repairs

Introduction

There are significant differences in the way RV systems work in comparison to home systems. My goal with this mod is to move those differences in air and heat closer together. We have totally separate heating and air conditioning systems, the short falls are there is little air movement when the heat is running and Gas furnace, alone, really tends to dry out the air, moreover, neither unit has a particularly accurate thermostat, this mod fixes that.

Changes in the System

Removing the analog thermostat and replacing with a digital is key to the entire operation. We are well aware of our optimal winter and summer temperature preferences and analog is so difficult to set up. Digital tends to be more “set and forget”...

Read More

RV Mod: Adding / Installing an RV Dinette

December 19, 2016 Trailer Mods / Repairs

Adding an RV Dinette Introduction / Description

We do quite a lot of RV living in the winter months. We have a hybrid and in the winter it just isn’t comfy sleeping in a tent. Subsequently, we were looking for a way to have a permanent bed, as well as a table for additional counterspace, work, and eating meals. We came up with, considered heavily, and acted upon a plan for a fairly thin table that takes up about 6 inches of walking space.

Our plan involved buying 2 table legs and a 12 inch plank. We have been using this new table for several days and, for us, it works out perfectly. Our RV has very little counter space, and for cooking, we needed just a bit more. This table is a total score!! For working on the laptop, it also works well.

Below is a video we made for the installatio...

Read More

Travel Trailer (RV) Mods!! Electric Water Heater Element

December 1, 2016 Trailer Mods / Repairs

texas-travelers

texas-travelers

This is a four part video series on choosing, gathering parts and tools, preparing for and finally installing an electric water heater element.  The only reason it is four parts is to keep each individual video around or below the 10 minute range.

Part 1:  Choosing the electric water heater system and gathering the parts and tools to do the job.

Unpacking and unboxing the parts for modding an Atwood Propane Water Heater and fitting it with an Electric Heating Element.

Also description of tools one might need for the job.

Parts:

Diamond Group HR6 Water Heater Parts Kit
Website
Light Switch with or Without Pilot Light
Single Gang Old Work Box or Similar

Tools:

6 Way Screwdriver
Electrical Wire Cutter / Stripper
Razor Knife
Wrenches / Pliers
Drill
Drill Bits 1/4 and 1...

Read More

Solar Charge Controller Woes ….. Disconnect Needed

November 29, 2016 Trailer Mods / Repairs

Funny thing happened the other day.  I was doing some electrical work and popped a GFCI plug.  Didn’t think too much about it, went on about my businness and finished the work.  A couple days later I went into the trailer and …. no lights.  Since I don’t plug in, ever …. this only meant one thing, dead battery.  As I looked into the reasons for a dead battery, I discovered that the Solar Charge controller was no longer functioning.  I have ordered a new one, and it is on its way.  I really need to design in a fail safe that disconnects the solar controller when we are plugged in to 110 at a campground.  It sort of makes sense that there could be a spike on the trailer chassis ground for a split second, if and when a GFCI pops, and if there were a spike …...

Read More